• 首页 | 期刊简介 | 编委会 | 投稿须知 | 出版道德规范 | 下载专区 | English
黄鹏飞,姚瑞霞,王龙,李腾辉,潘晓旭,苏飞*.2D C/SiC复合材料细观损伤机制及氧化对其影响的研究[J].实验力学,2018,33(1):69~76
2D C/SiC复合材料细观损伤机制及氧化对其影响的研究
On the mesoscopic damage mechanism of 2D C/SiC composite and effect of oxidation on damage mechanism
投稿时间:2016-11-09  修订日期:2017-02-23
DOI:10.7520/1001-4888-16-241
中文关键词:  2D C/SiC复合材料  细观机制  纤维氧化  裂纹萌生
英文关键词:2D C/SiC composites  mesoscopic mechanism  fiber oxidation  crack initiation
基金项目:国家重点基础研究发展计划(973计划)
作者单位
黄鹏飞 北京航空航天大学 航空科学与工程学院, 北京 100191 
姚瑞霞 北京航空航天大学 航空科学与工程学院, 北京 100191 
王龙 北京强度环境研究所可靠性与环境工程技术重点实验室, 北京 100076 
李腾辉 北京航空航天大学 航空科学与工程学院, 北京 100191 
潘晓旭 北京航空航天大学 航空科学与工程学院, 北京 100191 
苏飞* 北京航空航天大学 航空科学与工程学院, 北京 100191 
摘要点击次数: 916
全文下载次数: 253
中文摘要:
      为了观察分析C/SiC陶瓷基复合材料的细观损伤机制,利用划片切割机去除表面涂层,采用扫描电镜和配套的原位加载装置探究其细观损伤机理,以此结合宏观现象对其作出解释。本文以四点弯实验为基础,利用搭建的高温加热系统在不同高温环境下氧化材料。随着氧化的发生,得到C/SiC陶瓷基复合材料细观形貌以及破坏机制的变化规律。随着氧化程度的加强,发现材料基体以及纤维出现不同程度的烧蚀,界面层遭到破坏,弯曲强度逐渐降低。同时纤维的拔出、裂纹的萌生以及扩展方式发生了改变,从而导致不同破坏断口的出现。
英文摘要:
      In order to observe and analyze the mesoscopic damage mechanism of C/SiC ceramic matrix composite, the surface coating was removed first by using dicing cutter, and mesoscopic damage mechanism was studied by scanning electron microscope (SEM) and in-situ loading device. Based on above results and in combination with macroscopic phenomenon, mesoscopic damage mechanism is explained. Based on four-point bending experiment, a self-established high temperature heating system was used to oxidize the material under different high temperature conditions. With the occurrence of oxidation, the mesoscopic morphology and variation of damage mechanism of C/SiC ceramic matrix composite were obtained. With the increase of oxidation degree, it is found that the matrix and fiber of material are ablated at different degrees, the interface layer is destroyed, and the flexural strength is decreased gradually. At the same time, the pull-out of fiber, the mode of crack's initiation and propagation is changed, resulting in the appearance of different fracture surfaces.
查看全文  下载PDF阅读器
关闭

版权所有:《实验力学》编辑部
您是本站第 65194653 位访问者,今日一共访问1365次,当前在线人数: 0
技术支持:本系统由北京勤云科技发展有限公司设计